SCHIAVO, DANTE N

Abstract Rational: Talc pleurodesis is an effective intervention for preventing recurrent pleural effusions and pneumothoraces, particularly in non-surgical candidates. Due to its efficacy and safety, it is recommended as the most effective sclerosant for pleurodesis. However, in some cases, the initial pleurodesis fails, necessitating a repeat procedure. The efficacy of repeat talc pleurodesis after an initial failure is an area that requires further exploration. This study explores the safety and efficacy of repeat talc pleurodesis among patients who did not respond to the initial intervention. Methods: This retrospective study analyzed hospitalized patients who underwent 4g talc slurry pleurodesis from 2019 to 2024, focusing on demographics, comorbidities, initial pleurodesis failure, and recurrence rates. Pleurodesis failure was identified by lung sliding, recurrent effusion, or pneumothorax during the same hospitalization. The primary outcome was recurrence post-discharge, assessed by pleural effusion or pneumothorax within 180 days post-repeat pleurodesis. Results: This study included 94 patients (52.1% male, 47.9% female) with a mean age of 67.6. Among them, 79 (84%) received a single 4g dose of talc, while 15 (16%) received multiple 4g talc doses for initial pleurodesis. Recurrence occurred in 20 (25.3%) of the single-dose group and 1 (6.7%) of the multiple-dose group within 180 days, though the difference was not statistically significant (p=0.112). Recurrence-free rates were 93.6% at 30 days, 85.1% at 90 days, and 77.7% at 180 days. Of the 20 patients with recurrence after a single 4g dose of talc, 8 (40%) underwent repeat pleurodesis, with only one recurrence requiring surgical intervention. Additionally, there was no recurrence after repeat talc pleurodesis in the one patient with recurrence after receiving multiple 4g talc doses for initial pleurodesis. No associations were found between recurrence rates and factors like gender (p=0.213) or comorbidities (emphysema, COPD, lung malignancy). Chest pain was a common complaint, but no cases of respiratory distress were reported post-pleurodesis. Conclusion: The efficacy of initial talc pleurodesis (77.7%-93.6%) in this cohort aligns with existing literature. Multiple-dose talc pleurodesis effectively prevented recurrence in 93.3% of patients, with no reported respiratory distress. Additionally, repeat talc pleurodesis was successful in 87.5% of those with recurrence after an initial single 4g dose. These findings support multiple-dose talc pleurodesis and repeat talc pleurodesis as safe and effective options for preventing recurrence post-initial failure and post-repeat talc pleurodesis, respectively. Although no significant recurrence predictors were identified, future research could focus on patient-specific factors to enhance treatment selection and optimize outcomes.