Pagnano, Mark W.

AimsThis study aimed to determine outcomes of isolated tibial insert exchange (ITIE) during revision total knee arthroplasty (TKA).MethodsFrom 1985 to 2016, 270 ITIEs were performed at one institution for instability (55%, n = 148), polyethylene wear (39%, n = 105), insert fracture/dissociation (5%, n = 14), or stiffness (1%, n = 3). Patients with component loosening, implant malposition, infection, and extensor mechanism problems were excluded.ResultsSurvivorship free of any re-revision was 68% at ten years. For the indication of insert wear, survivorship free of any re-revision at ten years was 74%. Re-revisions were more frequent for index diagnoses other than wear (hazard ratio (HR) 1.9; p = 0.013), with ten-year survivorships of 69% for instability and 37% for insert fracture/dissociation. Following ITIE for wear, the most common reason for re-revision was aseptic loosening (33%, n = 7). For other indications, the most common reason for re-revision was recurrence of the original diagnosis. Mean Knee Society Scores improved from 54 (0 to 94) preoperatively to 77 (38 to 94) at ten years.ConclusionAfter ITIE, the risk and reasons for re-revision correlated with preoperative indications. The best results were for polyethylene wear. For other diagnoses, the re-revision rate was higher and the failure mode was most commonly recurrence of the original indication for the revision TKA. Cite this article: Bone Joint J 2021;103-B(6):1103–1110.

AimsIt remains difficult to diagnose early postoperative periprosthetic joint infection (PJI) following total knee arthroplasty (TKA). We aimed to validate the optimal cutoff values of ESR, CRP, and synovial fluid analysis for detecting early postoperative PJI in a large series of primary TKAs.MethodsWe retrospectively identified 27,066 primary TKAs performed between 2000 and 2019. Within 12 weeks, 169 patients (170 TKAs) had an aspiration. The patients were divided into two groups: those evaluated ≤ six weeks, or between six and 12 weeks postoperatively. The 2011 Musculoskeletal Infection Society (MSIS) criteria for PJI diagnosis in 22 TKAs. The mean follow-up was five years (two months to 17 years). The results were compared using medians and Mann-Whitney U tests and thresholds were analyzed using receiver operator characteristic curves.ResultsWithin six weeks, the median CRP (101 mg/l vs 35 mg/l; p = 0.011), synovial WBCs (58,295 cells/μl vs 2,121 cells/μl; p ≤ 0.001), percentage of synovial neutrophils (91% vs 71% (p < 0.001), and absolute synovial neutrophil count (ANC) (50,748 cells/μl vs 1,386 cells/μl (p < 0.001) were significantly higher in infected TKAs. Between six and 12 weeks, the median CRP (85 mg/l vs 5 mg/l (p < 0.001)), ESR (33 mm/hr vs 14 mm/hr (p = 0.015)), synovial WBCs (62,247 cells/μl vs 620 cells/μl (p < 0.001)), percentage of synovial neutrophils (93% vs 54% (p < 0.001)), and ANC (55,911 cells/μl vs 326 cells/μl (p < 0.001)) were also significantly higher in infected TKAs. Optimal thresholds at ≤ six weeks were: CRP ≥ 82 mg/l (sensitivity 70%, specificity 77%), synovial WBCs ≥ 8,676 cells/μl (83%, 90%), percentage of synovial neutrophils ≥ 88% (67%, 78%), and ANC ≥ 8,346 cells/μl (83%, 91%). Between six and 12 weeks, thresholds were: CRP ≥ 34 mg/l (90%, 93%), synovial WBCs ≥ 1,983 cells/μl (80%, 85%), percentage of synovial neutrophils ≥ 76% (80%, 81%), and ANC ≥ 1,684 cells/μl (80%, 87%).ConclusionEarly PJI after TKA should be suspected within six weeks if the CRP is ≥ 82 mg/l, synovial WBCs are ≥ 8,676 cells/μl, the percentage of synovial neutrophils is ≥ 88%, and/or the ANC is ≥ 8,346 cells/μl. Between six and 12 weeks, thresholds include a CRP of ≥ 34 mg/l, synovial WBC of ≥ 1,983 cells/μl, a percentage of synovial neutrophils of ≥ 76%, and/or an ANC of ≥ 1,684 cells/μl. Cite this article: Bone Joint J 2021;103-B(6 Supple A):177–184.

Background: The optimal strategy to address osseous deficiencies of the patella during revision total knee arthroplasty (TKA) remains controversial. One possible solution is a cemented biconvex patellar component used such that the non-articular convexity both improves fixation and makes up for bone loss. The aim of this study was to determine the outcomes of the use of biconvex patellar components in a large series of revision TKAs. Methods: From 1996 to 2014, 262 revision TKAs were performed at a single institution using a biconvex patellar component. Implant survivorship, clinical and radiographic results, and complications were assessed. The mean patient age at the TKA revision was 69 years, and 53% of the patients were female. The mean follow-up was 7 years. Results: The 10-year survivorship free of revision of the biconvex patellar component due to aseptic loosening was 96%. The 10-year survivorship free of any revision of the biconvex patellar component was 87%. The 10-year survivorship free of any rerevision and free of any reoperation was 75% and 70%, respectively. The mean Knee Society Score (KSS) improved from 45.4 before the index revision to 67.7 after it. The mean residual composite thickness seen on the most recent radiographs was 18.1 mm. In addition to the complications leading to revision, the most common complications were periprosthetic patellar fracture (6%), of which 3 required revision; superficial wound infection (6%) requiring antibiotic therapy only or irrigation and debridement; and arthrofibrosis (3%). Conclusions: In this cohort of 262 revision TKAs, biconvex patellar components used to treat marked patellar bone loss demonstrated excellent durability with a 10-year survivorship free of patellar rerevision due to aseptic loosening of 96%. The biconvex patellar components were reliable as evidenced by substantial improvements in clinical outcomes scores and a low risk of complications. Level of Evidence: Therapeutic Level IV . See Instructions for Authors for a complete description of levels of evidence.

Debate remains regarding the utility of mechanical axis alignment as a predictor of durability after total knee arthroplasty (TKA). Our study aimed to assess the effects of coronal alignment on implant durability, clinical outcomes, and radiographic results with a single fixed-bearing TKA design. All patients undergoing primary cemented TKA of a single design (Stryker Triathlon) from 2005–2007 with >10 years of follow-up and available pre-operative and post-operative hip–knee–ankle radiographs were included (n = 89). Radiographs were measured to determine coronal alignment and assessed for loosening. Mean preoperative mechanical axis alignment was −6° ± 6.7° (varus, range, −16°–23°), while mean post-operative alignment was −1° ± 2.7° (varus, range, −3°–15°). The aligned group was defined as knees with a post-operative mechanical axis of 0° ± 3° (n = 73) and the outlier group as those outside this range (n = 16). No patients underwent revision. Ten-year survivorship free from any reoperation was 99% and 100% in the aligned and outlier groups, respectively (p = 0.64). Knee Society scores improved significantly in both groups (p < 0.001) and did not differ at final follow-up (p = 0.15). No knees demonstrated radiographic evidence of loosening. Post-operative mechanical axis alignment within 3° of neutral was not associated with improved implant durability, clinical outcomes, or radiographic results at 10 years following primary TKA.

Background: Spinal anesthesia provides several benefits for patients undergoing total hip arthroplasty (THA) and total knee arthroplasty (TKA), but historically comes at the cost of slow and unpredictable return of lower-extremity motor function related to the use of long-acting local anesthetics. In this prospective, double-blinded, randomized clinical trial we sought to determine if an alternative local anesthetic, mepivacaine, would allow more consistent return of motor function compared with low-dose bupivacaine spinal anesthesia during primary THA and TKA. Methods: This trial was conducted at a single academic institution. Prior to trial initiation an internal pilot study determined that 154 patients were required to achieve 80% power. Patients were randomized in a 1:1 fashion with use of advanced computerized stratification based on procedure, age group, sex, and body mass index. Following the surgical procedure, motor function was assessed every 15 minutes in the nonoperative lower extremity according to the Bromage scale and discontinued once Bromage 0 was achieved (spontaneous movement at hip, knee, and ankle). Results: Return of lower-extremity function was more predictable in patients who received mepivacaine than in those who received low-dose bupivacaine. Among patients who received mepivacaine, 1% achieved motor function return beyond 5 hours compared with 11% of patients who received bupivacaine (p = 0.013). The mean time to return of lower-extremity motor function was 26 minutes quicker in patients who received mepivacaine (185 minutes; 95% confidence interval, 174 to 196 minutes) compared with low-dose bupivacaine (210 minutes; 95% confidence interval, 193 to 228 minutes) (p = 0.016). There were no significant differences in safety outcomes including pain scores, time to participation in physical therapy, incidence of orthostatic hypotension, urinary retention, or transient neurologic symptoms in patients receiving mepivacaine compared with low-dose bupivacaine. Conclusions: In patients undergoing primary THA and TKA, spinal anesthesia with mepivacaine allowed more consistent return of lower-extremity motor function compared with low-dose bupivacaine, without a concomitant increase in complications potentially associated with spinal anesthetics. This is particularly of value in an era of short-stay and outpatient surgical procedures. Level of Evidence: Therapeutic Level I . See Instructions for Authors for a complete description of levels of evidence.

Background: Total knee arthroplasties (TKAs) with cementless fixation have been studied in multiple series with varying success. The aim of this study was to prepare a systematic review of the literature to evaluate clinical outcomes and revtpdelision rates of patients undergoing contemporary cementless TKA. Methods: A search of PubMed and MEDLINE was conducted for English-language articles published between 2005 and 2018 to identify studies examining survivorship and clinical outcomes of cementless TKAs. Studies that reported clinical and/or radiographic outcomes were included. Data collected included the number of TKAs, implant utilized, primary diagnosis, mean age and follow-up, implant survivorship, complications, revisions, and clinical outcome scores. All hybrid constructs and revision TKAs were excluded. Poisson regression analysis was used to determine the revision incidence rates per 1,000 person-years. Results: Forty-three studies with 10,447 TKAs met inclusion criteria, of which 8,187 were primary cementless TKAs. The mean follow-up was 7 years. The revision incidence per 1,000 person-years was 4.8 for all cementless designs. The complication rate for all cementless TKAs was 6%, with deep venous thrombosis being the most common complication. The mean postoperative Knee Society Score and Functional Score were 92 and 83, respectively. Conclusions: While newer-generation cementless designs have shown improved survivorship and clinical outcomes compared with earlier-generation cementless designs, the literature for cementless designs remains limited when compared with cemented designs. Further studies are needed to determine if cementless TKA can achieve the same benefits that have been realized with cementless total hip arthroplasty. Level of Evidence: Therapeutic Level IV . See Instructions for Authors for a complete description of levels of evidence.

Aims Arthrodesis is rarely used as a salvage procedure for patients with a chronically infected total knee arthroplasty (TKA), and little information is available about the outcome. The aim of this study was to assess the reliability, durability, and safety of this procedure as the definitive treatment for complex, chronically infected TKA, in a current series of patients. Methods We retrospectively identified 41 patients (41 TKAs) with a complex infected TKA, who were treated between 2002 and 2016 using a deliberate, two-stage knee arthrodesis. Their mean age was 64 years (34 to 88) and their mean body mass index (BMI) was 39 kg/m2 (25 to 79). The mean follow-up was four years (2 to 9). The extensor mechanism (EM) was deficient in 27 patients (66%) and flap cover was required in 14 (34%). Most patients were host grade B (56%) or C (29%), and limb grade 3 (71%), according to the classification of McPherson et al. A total of 12 patients (29%) had polymicrobial infections and 20 (49%) had multi-drug resistant organisms; fixation involved an intramedullary nail in 25 (61%), an external fixator in ten (24%), and dual plates in six (15%). Results Survivorship free from amputation, persistent infection, and reoperation, other than removal of an external fixator, at five years was 95% (95% confidence interval (CI) 89% to 100%), 85% (95% CI 75% to 95%), and 64% (95% CI 46% to 82%), respectively. Reoperation, other than removal of an external fixator, occurred in 13 patients (32%). After the initial treatment, radiological nonunion developed in ten knees (24%). Nonunion was significantly correlated with persistent infection (p = 0.006) and external fixation (p = 0.005). Of those patients who achieved limb salvage, 34 (87%) remained mobile and 31 (79%) had ‘absent’ or ‘minimal’ pain ratings. Conclusion Knee arthrodesis using a two-stage protocol achieved a survivorship free from amputation for persistent infection of 95% at five years with 87% of patients were mobile at final follow-up. However, early reoperation was common (32%). This is not surprising as this series included worst-case infected TKAs in which two-thirds of the patients had a disrupted EM, one-third required flap cover, and most had polymicrobial or multi-drug resistant organisms. Cite this article: Bone Joint J 2020;102-B(6 Supple A):170–175.

AimsMetaphyseal fixation during revision total knee arthroplasty (TKA) is important, but potentially difficult when using historical designs of cone. Material and manufacturing innovations have improved the size and shape of the cones which are available, and simplified the required bone preparation. In a large series, we assessed the implant survivorship, radiological results, and clinical outcomes of new porous 3D-printed titanium metaphyseal cones featuring a reamer-based system.MethodsWe reviewed 142 revision TKAs in 139 patients using 202 cones (134 tibial, 68 femoral) which were undertaken between 2015 and 2016. A total of 60 involved tibial and femoral cones. Most cones (149 of 202; 74%) were used for Type 2B or 3 bone loss. The mean age of the patients was 66 years (44 to 88), and 76 (55 %) were female. The mean body mass index (BMI) was 34 kg/m2(18 to 60). The patients had a mean of 2.4 (1 to 8) previous operations on the knee, and 68 (48%) had a history of prosthetic infection. The mean follow-up was 2.4 years (2 to 3.6).ResultsSurvivorship free of cone revision for aseptic loosening was 100% and survivorship free of any cone revision was 98%. Survivorships free of any revision and any reoperation were 90% and 83%, respectively. Five cones were revised: three for infection, one for periprosthetic fracture, and one for aseptic tibial loosening. Radiologically, three unrevised femoral cones appeared loose in the presence of hinged implants, while the remaining cones appeared stable. All cases of cone loosening occurred in patients with Type 2B or 3 defects. The mean Knee Society score (KSS) improved significantly from 50 (0 to 94) preoperatively to 87 (72 to 94) (p < 0.001). Three intraoperative fractures with cone impaction (two femoral, one tibial) healed uneventfully.ConclusionNovel 3D-printed titanium cones, with a reamer-based system, yielded excellent early survivorship and few complications in patients with severe bone loss undergoing difficult revision TKA. The diversity of cone options, relative ease of preparation, and outcomes rivalling those of previous designs of cone support their continued use. Cite this article: Bone Joint J 2020;102-B(6 Supple A):107–115.

AimsVarus-valgus constrained (VVC) implants are often used during revision total knee arthroplasty (TKA) to gain coronal plane stability. However, the increased mechanical torque applied to the bone-cement interface theoretically increases the risk of aseptic loosening. We assessed mid-term survivorship, complications, and clinical outcomes of a fixed-bearing VVC device in revision TKAs.MethodsA total of 416 consecutive revision TKAs (398 patients) were performed at our institution using a single fixed-bearing VVC TKA from 2007 to 2015. Mean age was 64 years (33 to 88) with 50% male (199). Index revision TKA diagnoses were: instability (n = 122, 29%), aseptic loosening (n = 105, 25%), and prosthetic joint infection (PJI) (n = 97, 23%). All devices were cemented on the epiphyseal surfaces. Femoral stems were used in 97% (n = 402) of cases, tibial stems in 95% (n = 394) of cases; all were cemented. In total, 93% (n = 389) of cases required a stemmed femoral and tibial component. Femoral cones were used in 29%, and tibial cones in 40%. Survivorship was assessed via competing risk analysis; clinical outcomes were determined using Knee Society Scores (KSSs) and range of movement (ROM). Mean follow-up was four years (2 to 10).ResultsThe five-year cumulative incidence of subsequent revision for aseptic loosening and instability were 2% (95% confidence interval (CI) 0.2 to 3, number at risk = 154) and 4% (95% CI 2 to 6, number at risk = 153), respectively. The five-year cumulative incidence of any subsequent revision was 14% (95% CI 10 to 18, number at risk = 150). Reasons for subsequent revision included PJI (n = 23, of whom 12 had previous PJI), instability (n = 13), and aseptic loosening (n = 11). The use of this implant without stems was found to be a significant risk factor for subsequent revision (hazard ratio (HR) 7.58 (95% CI 3.98 to 16.03); p = 0.007). KSS improved from 46 preoperatively to 81 at latest follow-up (p < 0.001). ROM improved from 96° prerevision to 108° at latest follow-up (p = 0.016).ConclusionThe cumulative incidence of subsequent revision for aseptic loosening and instability was very low at five years with this fixed-bearing VVC implant in revision TKAs. Routine use of cemented and stemmed components with targeted use of metaphyseal cones likely contributed to this low rate of aseptic loosening. Cite this article: Bone Joint J 2020;102-B(4):458–462.

Background: Evidence-based, procedure-specific guidelines for prescribing opioids are urgently needed to optimize pain relief while minimizing excessive opioid prescribing and potential opioid diversion in our communities. A multidisciplinary panel at our institution recently developed procedure-specific guidelines for discharge opioid prescriptions for common orthopaedic surgical procedures. The purpose of this study was to evaluate postoperative opioid prescription quantities, variability, and 30-day refill rates before and after implementation of the guidelines. Methods: This retrospective cohort study was conducted at a single academic institution from December 2016 to March 2018. Guidelines were implemented on August 1, 2017, with a recommended maximum opioid prescription quantity for 14 common orthopaedic procedures. Patients who underwent these 14 procedures during the period of December 2016 to May 2017 made up the pre-guideline cohort (n = 2,223), and patients who underwent these procedures from October 2017 to March 2018 made up the post-guideline cohort (n = 2,300). Opioid prescription quantities were reported as oral morphine equivalents (OME), with medians and interquartile ranges (IQRs). Four levels were established for recommended prescription maximums, ranging from 100 to 400 OME. Results: In the pre-guideline cohort, the median amount of prescribed opioids across all procedures was 600 OME (IQR, 390 to 863 OME), which decreased by 38% in the post-guideline period, to a median of 375 OME (IQR, 239 to 400 OME) in the post-guideline cohort (p < 0.001). The 30-day refill rate did not change significantly, from a rate of 24% in the pre-guideline cohort to 25% in the post-guideline cohort (p = 0.43). Multivariable analysis demonstrated that guideline implementation was the factor most strongly associated with prescriptions exceeding guideline maximums (odds ratio [OR] = 9.9; p < 0.001). Age groups of <80 years (OR = 2.0 to 2.4; p < 0.001) and males (OR = 1.2; p = 0.025) were also shown to have higher odds of exceeding guideline maximums. Conclusions: Procedure-specific guidelines are capable of substantially decreasing opioid prescription amounts and variability. Furthermore, the absence of change in refill rates suggests that pain control remains similar to pre-guideline prescribing practices. Evidence-based guidelines are a readily employable solution that can drive rapid change in practice and enhance the ability of orthopaedic surgeons to provide responsible pain management.